Solubility behavior of polymorphs I and II of mefenamic acid in solvent mixtures

The dissolution profile and solubility of two polymorphic forms of mefenamic acid were studied in solvent mixtures of ethanol-water and ethyl acetate-ethanol. The solubility parameter (delta) was used to study the effect of polarity on the solubility behavior of the two polymorphs. Differential scanning calorimetry and infrared spectroscopy were performed on the original powders and on the solid phases after contact with the solvent systems for the characterization and identification of the polymorphs. The dissolution rates of both polymorphs is greater in the less polar mixtures (ethyl acetate-ethanol) of lower solubility parameter values. Form II showed larger dissolution rates and saturation concentrations than Form I in all the solvent systems studied. The solid phase of Form II converts totally to Form I after equilibration with the solvents. The rate of conversion was faster in the least polar mixtures. The solubility of both polymorphs reaches a single maximum at 80% ethyl acetate in ethanol, delta = 20.09 MPa1/2. The modified extended Hildebrand method was used to predict the solubility profile of each polymorph. A single equation was obtained for both polymorphs which includes the solubility parameter of the mixtures and the logarithm of the solubility mole fraction of each polymorph in water. The Hildebrand solubility parameter of mefenamic acid is independent of the crystalline form and was determined from two methods giving quite similar values, delta 2 = 20-21 MPa1/2.