Chronic toxicity/oncogenicity study of styrene in CD-1 mice by inhalation exposure for 104 weeks

Groups of 70 male and 70 female Charles River CD-1 mice were exposed whole body to styrene vapor at 0, 20, 40, 80 or 160 ppm 6 h per day 5 days per week for 98 weeks (females) or 104 weeks (males). The mice were observed daily; body weights, food and water consumption were measured periodically, a battery of hematological and clinical pathology examinations were conducted at weeks 13, 26, 52, 78 and 98 (females)/104 (males). Ten mice of each gender per group were pre-selected for necropsy after 52 and 78 weeks of exposure and the survivors of the remaining 50 of each gender per group were necropsied after 98 or 104 weeks. An extensive set of organs from the control and high-exposure mice were examined histopathologically, whereas target organs, gross lesions and all masses were examined in all other groups. Styrene had no effect on survival in males. Two high-dose females died (acute liver toxicity) during the first 2 weeks; the remaining exposed females had a slightly higher survival than control mice. Levels of styrene and styrene oxide (SO) in the blood at the end of a 6 h exposure during week 74 were proportional to exposure concentration, except that at 20 ppm the SO level was below the limit of detection. There were no changes of toxicological significance in hematology, clinical chemistry, urinalysis or organ weights. Mice exposed to 80 or 160 ppm gained slightly less weight than the controls. Styrene-related non-neoplastic histopathological changes were found only in the nasal passages and lungs. In the nasal passages of males and females at all exposure concentrations, the changes included respiratory metaplasia of the olfactory epithelium with changes in the underlying Bowman's gland; the severity increased with styrene concentration and duration of exposure. Loss of olfactory nerve fibers was seen in mice exposed to 40, 80 or 160 ppm. In the lungs, there was decreased eosinophilia of Clara cells in the terminal bronchioles and bronchiolar epithelial hyperplasia extending into alveolar ducts. Increased tumor incidence occurred only in the lung. The incidence of bronchioloalveolar adenomas was significantly increased in males exposed to 40, 80 or 160 ppm and in females exposed to 20, 40 and 160 ppm. The increase was seen only after 24 months. In females exposed to 160 ppm, the incidence of bronchiolo-alveolar carcinomas after 24 months was significantly greater than in the controls. No difference in lung tumors between control and styrene-exposed mice was seen in the intensity or degree of immunostaining, the location of tumors relative to bronchioles or histological type (papillary, solid or mixed). It appears that styrene induces an increase in the number of lung tumors seen spontaneously in CD-1 mice.