Fermentation study for the production of hepatitis B virus pre-S2 antigen by the methylotrophic yeast Hansenula...

Various physico-chemical parameters have been studied in order to improve the production of hepatitis B virus pre-S2 antigen (middle surface antigen) by the methylotrophic yeast Hansenula polymorpha. Antigen production was done in two steps: first, production of cells on glycerol (Phase 1), followed by induction of antigen expression with methanol (Phase 2). Dense cultures of H. polymorpha, equivalent to 35-40 g/l (dry weight), were readily obtained in small fermenters using minimal medium containing glycerol as carbon source. Antigen expression in this minimal medium, after induction with methanol, was however, low and never exceeded 1.6 mg/l of culture. Antigen production was greatly enhanced by adding complex organic nitrogen sources along with methanol at induction time; yeast extract was the best of all the sources tested. In shake flasks, antigen production was proportional to yeast extract concentration up to 7% (w/v) yeast extract, it became clear the the nutritional conditions for good antigen expression were different from those for good biomass production. The effects of yeast extract were reproduced in small fermenters: antigen levels reached 8-9 mg/l in medium containing 6% (w/v) yeast extract during induction with methanol. The mechanisms of yeast extract's effects are still unknown but are probably nutritional. The recombinant H. polymorpha strain produced both periplasmic and intracellular antigen. The periplasmic antigen was shown to be present as 20-22-nm particles and was therefore immunogenic. Immunoblotting indicated that part of the pre-S2 antigen was present as a 24-kDa degradation product. These studies have led to a 140-fold increase in volumetric productivity of antigen and to a 4.6-fold increase in specific production.