Reduction of detection limits of the direct deposition GC/FT-IR interface by surface-enhanced infrared absorption

Even though the interface of gas chromatography (GC) and mass spectrometry (MS) is by far the most popular way of identifying molecules eluting from a GC in real time, the identification of compositional isomers by MS is equivocal at best. Much better results would be found by infrared spectrometry (IR) if the sensitivity of the GC/IR interface could be improved. In this paper, we show how the smallest quantity of molecules injected into a GC for which an identifiable infrared spectrum can be measured on-line has been reduced by a factor of 10 below the detection limit of the most sensitive current technique. A commercial direct deposition interface between a GC and a Fourier transform infrared spectrometer was modified by vapor-depositing an island film of silver on the surface of the zinc selenide substrate. Band intensities in the spectra of molecules located within approximately 4 nm of the surface of the silver islands were increased by at least 1 order of magnitude through surface-enhanced infrared absorption (SEIRA). The effectiveness of this approach was illustrated by comparing the limits of identification of butylbenzene isomers measured with and without the silver film. Comparison with the spectra of the same molecules measured by mass spectrometry showed the increased sensitivity and specificity of the GC/SEIRA interface.