Study of the coalescence of acoustic bubbles as a function of frequency, power, and water-soluble additives

The effect that surface-active solutes, such as aliphatic alcohols and sodium dodecyl sulfate (SDS), have on the extent of bubble coalescence in liquids under different sonication conditions has been investigated by measuring the volume change of the solution following a period of sonication. In general, the adsorption of surface-active solutes onto the bubble surface retards bubble coalescence. Within the limitations of the measurement method and the systems studied, bubble coalescence does not appear to be dependent on the applied acoustic power. Also, varying the applied acoustic frequency has a minimal effect on the extent of bubble coalescence in systems where long-range electrostatic repulsion between bubbles, imparted by the adsorbed surface-active solutes, dominates. However, when short-range steric repulsion (or other short-range repulsive forces) is the primary factor in inhibiting bubble coalescence, the dependence on the applied acoustic frequency becomes apparent, with less coalescence inhibition at higher frequencies. It is also concluded that SDS does not reach an equilibrium adsorption level at the bubble/solution interface under the sonication conditions used. On the basis of this conclusion, a method is proposed for estimating nonequilibrium surface excess values for solutes that do not fully equilibrate with the bubble/solution interface during sonication. For the case of SDS in the presence of excess NaCl, the method was further employed to estimate the maximum lifetime of bubbles in a multibubble field. It was concluded that an acoustic bubble in a multibubble field has a finite lifetime, and that this lifetime decreases with increasing applied frequency, ranging from up to 0.35 +/- 0.05 ms for 213 kHz to 0.10 +/- 0.05 ms for 1062 kHz. These estimated lifetimes equate to a bubble in a multibubble field undergoing an upper limit of 50-200 oscillations over its lifetime for applied ultrasound frequencies between 200 kHz and 1 MHz.