Influence of free-stall base on tarsal joint lesions and hygiene in dairy cows

The objective was to quantify the incidence of tarsal lesions and level of hygiene by stall bed type. Cows were scored on 100 dairies from Wisconsin, Minnesota, Indiana, Iowa, and New York in the fall and winter. Thirty-eight dairies used rubber-filled mattresses (RFM), 27 had sand beds, 29 had waterbeds, and 6 used compost packs (CPk). Stocking density, stall dimensions, bedding amount, bedding frequency, and type of bedding were recorded. One pen of early-lactation multiparous cows on each dairy was scored based on injury of the tarsal joints at the lateral and medial surfaces and tuber calcis at the dorsal, lateral, and medial surfaces. A tarsal score of 1 represented hair loss, 2 was moderate, and 3 indicated severe swelling. Differences between bed types in the percentages of cows with lesions were tested with one-way ANOVA by lesion severity and incidence, with farm as the experimental unit. Cows on sand beds or waterbeds had fewer lesion scores of 1, 2, and 3 than those on RFM. The percentages of score 1 were 54.6 +/- 4.4 (RFM), 22.5 +/- 4.7 (sand), and 29.8 +/- 4.3 (waterbed), whereas the percentages of score 2 were 14.0 +/- 1.4, 2.3 +/- 1.5, and 5.0 +/- 1.4, and of score 3 were 3.0 +/- 0.4, 0.2 +/- 0.4, and 0.4 +/- 0.4. Cows on CPk had no lesions. Hygiene scores ranged from 1 to 5, with 1 being clean and 5 soiled. The percentages of hygiene score 1 were 0 (compost), 0.4 (RFM), 0.4 (sand), and 0.4 (waterbeds); those with score 2 were 79.0, 84.0 +/- 0.01, 73.2 +/- 0.01, and 80.4 +/- 0.01; with score 3 were 20.3, 15.2 +/- 0.01, 23.8 +/- 0.01, and 18.6 +/- 0.01; with score 4 were 0.8, 0.005 +/- 0.001, 0.006 +/- 0.001, and 0.025 +/- 0.003; and with score 5 was 0 for all bed types. Cows on RFM and waterbeds had improved hygiene compared with cows on sand beds. There was no difference in somatic cell count (SCC) by bed type. The percentage of cows in fourth lactation or greater on waterbeds (19.8 +/- 1.8) was greater than those on RFM (13.3 +/- 1.6) or on sand (13.5 +/- 1.8). The percentage culled was lower for cows on waterbeds than on RFM (22.8 +/- 1.5 vs. 29.4 +/- 1.4). Score 3 tarsal lesions were correlated (r = 0.60) with SCC. The length of the sand bed was correlated with a greater percentage of mature cows. The SCC was correlated with the percentage of cows reported lame on the day of the visit (r = 0.45) and with neck rail height (r = -0.26). On dairies with RFM, severe lesions (r = 0.60), death losses (r = 0.52), and percentage of the herd reported lame on the day of the visit (r = 0.52) were all correlated with the SCC. Dairies with higher percentages of lesions had higher SCC, death losses, lameness, and culling rates. Adding bedding several times per week may reduce the incidence of lesions.