Evaluation of self-dissolving needles containing low molecular weight heparin (LMWH) in rats

Feasibility study of self-dissolving needles containing polysaccharide was performed. Low molecular weight heparin (LMWH) was used as a representative polysaccharide. Using chondroitin, dextran and dextrin as the base, self-dissolving needles (SDN) were prepared. The obtained SDNs were evaluated in rat absorption experiment, where pharmacological availability (PA) was calculated by comparing the plasma anti-Xa activity vs. time curves between SDNs and i.v. solution. After the insertion of SDNs to rats skin where the doses of LMWH were 25, 50 and 100 IU/kg, plasma samples were collected for 6h and anti-Xa activity was measured as the pharmacological index of LMWH. The anti-Xa level was maintained above 0.2 IU/ml, the therapeutic level, for about 2h at a dose of 100 IU/kg. Almost the same PAs of LMWH were obtained with dextran and dextrin SDNs, 97.7% and 102.3%, though lower PA was obtained with chondroitin SDN, 81.5%. In vitro dissolution experiment showed that LMWH was released from dextran, dextrin and chondroitin SDNs within 10 min. The T(50%)s were 0.84+/-0.06 min for dextran SDN, 1.07+/-0.12 min for chondroitin SDN and 2.11+/-0.31 min for dextrin SDN, respectively. Plasma anti-Xa activity vs. time profiles showed good dose-dependency in the 25-100 IU/kg range and high PAs were obtained, 90.0% for 25 IU/kg, 95.4% for 50 IU/kg and 97.7% for 100 IU/kg from dextran SDNs. Stability experiment was performed with dextran SDNs for 3 months. Above 97% of LMWH were remained in SDNs under three different conditions, -80, 4 and 40 degrees C. These results suggest the usefulness of SDN to polysaccharide drug.