A comparison of some methods of estimating volumetric mass-transfer coefficients in an external-loop airlift...

Volumetric mass-transfer coefficients were measured in an 11-L external-loop airlift fermenter with deionized water, a fermentation medium, and during a fermentation. Both a Mackareth oxygen electrode and a novel rapid-response probe were used. When the conventional step-change dynamic method was used for water, the long, nonlinear response time of the Mackareth electrode made correction of its readings difficult; this problem did not occur when the rapid-response probe was used. A comparison was made with a method of mass-transfer coefficient determination which does not involve any assumptions about the gas residence time distribution. However, this method requires that the liquid phase is well-mixed and this requirement was not met in the airlift fermenter. Comparison of the present results with other K(L) a determinations for airlift fermenters showed that K(L) a in water depends on the active gas holdup, the value of K(L) a/epsilon at 20 degrees C being ca. 0.37 s(-1). Although higher gas holdups were obtained with the fermentation medium than for water, the values of K(L) a/epsilon were lower, ca. 0.22 s(-1) at 20 degrees C.