Covalent immobilization of lipase in organic solvents

Lipase from Rhizopus sp. has been immobilized covalently on tresyl activated silica. Three different coupling media were evaluated: aqueous buffer, n-hexane, and a microemulsion based on n-hexane, aqueous buffer, and the nonionic surfactant triethylene glycol monododecyl ether. In addition, coupling via a very long, hydrophilic spacer arm, polyethylene glycol 1500 (PEG 1500), was compared with attachment to the silica via a short silane bridge only. The enzyme preparations were tested in hydrolysis and transesterification reactions. In the hydrolysis no marked differences in activity were found between the coupling media used. In the transesterification, on the other hand, the choice of immobilization medium had a very large effect on lipase activity, the preparation from microemulsion being the most active one. The use of the hydrophilic spacer had a large effect on activity in the hydrolysis reaction. Whereas direct coupling gave an activity of immobilized lipase of 26-34% of that of free enzyme, depending on the reaction medium, lipase bound via the spacer exhibited 56-67% activity. The latter values are considerably higher than previously reported in the literature for covalently immobilized lipase. The hydrophilic spacer had no effect on enzyme activity in the transesterification, however, a fact which is attributed to the hydrophobic medium of this reaction. The spacer is incompatible with the reaction medium and will, therefore, adsorb on the particles rather than stretch out into the bulk phase. The stability of the bound lipase was extremely good, no loss in activity being observed after a period of three weeks in aqueous solution of 37 degrees C.