Possibility of heat sterilization of liposomes

Several kinds of liposomes were sterilized at 121 degrees C for 20 min. They tended to aggregate after heat sterilization (HS) in saline, while no aggregation was observed in an isotonized sugar or polyol solution. The dispersions containing egg phosphatidylcholine (EggPC) with a high peroxide value (POV) turned slightly yellowish after HS. This color change was prevented by using EggPC with a low POV, hydrogenated EggPC (H-EggPC) or dipalmitoylphosphatidylcholine (DPPC). Nitrogen gas bubbling at neutral pH also prevented the color change, but vitamin E did not. The particle size of the EggPC liposomes extruded through a 0.4 micron membrane filter did not change significantly after HS, whereas the H-EggPC or DPPC liposomes extruded through a 0.8 micron membrane filter tended to be reduced in size. On this change the type of medium had a considerable influence. The anionic 6-carboxyfluorescein leaked from the negatively charged liposomes (EggPC/cholesterol (Chol)/egg phosphatidylglycerol) during HS, while no leakage was observed from the positively charged liposomes (EggPC/Chol/stearylamine) not only during HS but also during a long period of storage. It was suggested that sterilization of liposomes by heating was practicable as well as that by filtration, if the liposomes were prepared as follows: the charged liposomes made of lipids with low POV's were dispersed in a sugar or polyol solution adjusted to nearly pH 6.5, where the amount of dissolved oxygen was minimized. An ionic water-soluble drug had to be encapsulated in the oppositely charged liposomes.