Ileal digestibility of amino acids of unheated and autoclaved pea protein concentrate in broilers

The effects of autoclaving 2 varieties of micronized (fine grinding) pea protein concentrate (PPC) on the ileal digestibility (ID) of CP and amino acids (AA) were studied in broilers. There was a control diet based on fermented soybean meal (FSBM) and 4 extra diets in which the FSBM was substituted on a CP basis by PPC from 2 different pea cultivars (PPC-1 and PPC-2), either unheated or autoclaved. Chicks were fed a common diet from 1 to 17 d of age and, then, their respective experimental diets from 18 to 21 d of age. Each treatment was replicated 6 times. Autoclaving reduced trypsin inhibitor activity (TIA) but had little effect on the saponin content of the PPC. The apparent ID (AID) of CP was similar for the FSBM and the unheated PPC and lower for both than for the autoclaved PPC. Autoclaving improved (P < 0.001) the AID of CP (87.6 vs. 82.2%) and most indispensable AA (e.g., 92.1 vs. 88.8% for Lys and 83.6 vs. 76.5% for Thr) of the PPC. The improvement in CP and AA digestibility with autoclaving varied with the PPC used and was consistent with the reduction in TIA observed (9.4 to 2.8 mg/g for PPC-1 vs. 9.1 to 5.3 mg/g for PPC-2). The standardized ID (SID) of most indispensable AA was similar for the FSBM and the PPC-2 and higher for both than for the PPC-1 (P < 0.05). For Lys, the lowest SID value was observed for the FSBM and the highest for the PPC-2 either unheated or autoclaved. It is concluded that the ID of the AA of the PPC improved with heating and was in general higher for the autoclaved PPC than for the FSBM. Consequently, heat processed PPC is a good alternative to FSBM and unheated PPC in starter diets for broilers.