Efficient harvesting of Chaetoceros calcitrans for biodiesel production

Harvesting is one of the key challenges to determine the feasibility of producing biodiesel from algae. This paper presents experimental results for a cost-effective system to harvest Chaetoceros calcitrans, using natural sedimentation, flocculation, and inducing pH. No efficient sedimentation of microalgal cells was observed only by gravity. By alkalinity-induced flocculation, at a pH value of 9.51, 86% recovery of the cells was achieved with a sedimentation rate of 125 cm/h and a concentration factor (CF) of 4 (volume/volume (v/v)) in 10 min. The maximum photochemical quantum yield of photosystem II (Fv/Fm) of concentrated cells was almost the same as fresh culture (0.621). Commercial flocculants, aluminium sulphate and poly-aluminium chloride (PAC), were also successful in harvesting the studied algal cells. Optimum concentration of aluminium sulphate (AS) could be concluded as 10 ppm with 87.6% recovery and 7.10 CF (v/v) in 30 min for cost-efficient harvesting, whereas for PAC it was 20 ppm with 74% recovery and 6.6 CF (v/v). Fv/Fm yields of concentrated cells with AS and PAC showed a 1% reduction compared to fresh culture. Mg+2 was the triggering ion for alkalinity-induced flocculation in the conditions studied. The rheology behaviour of the concentrated cells was Newtonian with values between 2.2×10(-3) and 2.3×10(-3) Pa s at 30°C.