Preparation and characterization of micronized ellagic acid using antisolvent precipitation for oral delivery

In this work, poorly water soluble phytochemical ellagic acid (EA) was micronized to increase its solubility and thereby the bioavailability during antisolvent precipitation process using N-methyl pyrrolidone (NMP) as solvent and deionized water as antisolvent. The micronized EA (m-EA) freeze-dried powder was prepared by the subsequent lyophilization process. The effects of various experimental parameters on the mean particle size (MPS) of m-EA suspension (m-EAS) in the antisolvent precipitation process were investigated. MPS and production efficiency were taken into account comprehensively to obtain the optimum conditions of antisolvent precipitation. Under the optimum conditions, m-EA freeze-dried powder with a MPS of 429.2 ± 7.6 nm was obtained. The physico-chemical properties of m-EA freeze-dried powder were detected by scanning electron microscope (SEM), Fourier transform infrared spectroscopy (FTIR), liquid chromatography-tandem mass spectrometry (LC-MS/MS), X-ray diffraction (XRD), differential scanning calorimetry (DSC) and thermogravimetric analysis (TGA). The results indicated m-EA kept the same chemical structure with raw EA, but the crystallinity was greatly reduced. Furthermore, a comparison of the 50% inhibition concentration (IC50) values revealed that m-EA was more effective than raw EA in scavenging 2,2-diphenyl-1-picrylhydrazyl (DPPH) radical. Meanwhile, m-EA also showed higher reducing power. Moreover, the residual amount of NMP was lower than the International Conference on Harmonization limit (530 ppm) for solvents. The dissolution rate of m-EA was approximately 2 times of raw EA. Moreover, the solubility of m-EA was about 6.5 times of raw EA. Meanwhile, the bioavailability of m-EA increased about 2 times compared with raw EA via oral administration.