Simultaneous removal of Cr(VI) and acid orange 7 from water solution by dielectric barrier discharge plasma

A feasibility study was conducted for simultaneous removal of hexavalent chromium (Cr(VI)) and azo dye acid orange 7 (AO7) by the dielectric barrier discharge (DBD) plasma. The results showed that there was a synergistic effect between Cr(VI) reduction and AO7 degradation. The presence of Cr(VI) enhanced the degradation efficiency of AO7. Meanwhile, the removal efficiency of Cr(VI) also increased in the presence of AO7. Under acidic conditions (pH = 3.0), the reduction efficiency of Cr(VI) was higher (approximately 94%). However, the presence of Cr(VI) diminished the effect of pH on the AO7 degradation efficiency. By increasing the input voltage from 80 to 120 V, the removal efficiencies of Cr(VI) and AO7 were observably increased from 54% to 88% and 62% to 89%, respectively. Adding organic matters inhibited the degradation of AO7 and promoted the reduction of Cr(VI). The addition of Cu(II), Co(II), Ni(II), Mn(II) and Fe(III) could inhibit the Cr(VI) reduction, but not significantly affect the degradation of AO7. The degradation intermediates of AO7 were identified by LC-MS/MS system and a possible degradation pathway was proposed. This study showed that the DBD plasma can simultaneously remove Cr(VI) and AO7, which provided a new idea for the actual wastewater treatment.