Effect of basic oxygen furnace slag addition on enhanced alkaline sludge fermentation and simultaneous phosphate...

This study presents a promising approach that enhances the sludge fermentation by using basic oxygen furnace (BOF) slag as an alkaline source for the first time. BOF slag added to the reactors could maintain a stable alkaline condition due to continuous release of Ca(OH)₂ from slag. The reactor pH could be adjusted to a target value by the choice of the BOF slag dose. Concentrations of soluble chemical oxygen demand (sCOD) and short-chain carboxylates (SCCs) were substantially increased in the presence of BOF slag. At a BOF slag mass to sludge volume ratio of 1/10 g slag/L sludge, the reactor pH was maintained at 10 and the concentration of SCCs produced was the highest (i.e., 3510 mg COD L^-1 from 14,000 mg VS L^-1 of sludge mixture), followed by B/S ratios of 1/20, 1.50, 1/5, and 1/2.5 g slag L^-1 sludge with reactor pH of 9.4, 8.9, 10.5, and 11, respectively. Our data suggest that the pH value that best facilitates the degradation of sludge into SCCs and inhibit the conversion of SCCs into biogas is around 10. Interestingly, compositions of the accumulated SCCs varied greatly depending on the BOF slag dose. BOF slag showed phosphorus removal ability due to enhanced precipitation of Ca-PO₄^3--P complexes, which significantly lowered PO₄^3- concentration of the reactor effluent.