Fermentation of flaxseed cake increases its nutritional value and utilization in ducklings

Flaxseed cake (FSC) is a potential alternative feed source in poultry. However, cyanogenetic glycosides limit its widespread use in feed. In this study, we optimized the parameters of fermentation by Aspergillus niger and Candida utilis and compared the growth performance, serum lipid parameters, and organ indexes of Cherry Valley duckling feed with unfermented FSC (UFSC) or fermented FSC (FFSC). A total of 420 one-day-old male Cherry Valley ducklings were randomly assigned into a 1 plus 2 × 3 factorial design including 2 different FSC resources (UFSC and FFSC) at 3 levels (50, 100, or 150 g/kg) for 3 wk. Each treatment group included 6 pens with 10 ducklings per pen. The hydrocyanic acid (HCN) level was reduced under the following conditions: 1:0.8 FSC:water (w:v), inoculum ratio of 1 mL:1 mL, 30°C, and 60 h. FFSC had higher crude protein (CP) and calcium (Ca) levels and lower HCN levels compared with UFSC (P < 0.05). There was no interactive effect between FSC sources and levels on growth performance. Final body weight (FBW), average daily feed intake (ADFI), and average daily gain (ADG) in UFSC groups and ADFI in FFSC groups decreased linearly with increasing FSC levels (P < 0.01). There were no differences in FBW, ADG, or feed:gain ratio (F/G) among FFSC groups, and all 7 FSC groups had no differences in the F/G ratio (P > 0.05). Dietary FSC supplementation decreased triglyceride (TG) (P < 0.01), total cholesterol (TC) (P < 0.01), high-density lipoprotein (HDL) (P = 0.01), and low-density lipoprotein (LDL) (P < 0.01). No interactive effect between FSC levels and sources was observed for serum TG, TC, HDL, or LDL. Ducklings fed FFSC had lower TG (P < 0.01), TC (P = 0.05), and LDL (P < 0.01) levels compared with ducklings fed UFSC. The 150 g/kg FFSC group had the lowest TG, TC, HDL, and LDL levels among all 7 groups. Flaxseed cake supplementation decreased the relative weight of the left breast, but FFSC increased the relative weight of the gizzard compared with UFSC. In conclusion, fermentation could increase the nutritional value and usage of FSC in ducklings.