Methods for simultaneous determination of legacy and insensitive munition (IM) constituents in aqueous,...

Currently, no standard method exists for analyzing insensitive munition (IM) compounds in environmental matrices, with or without concurrent legacy munition compounds, resulting in potentially inaccurate determinations. The primary objective of this work was to develop new methods of extraction, pre-concentration, and analytical separation/quantitation of 17 legacy munition compounds along with several additional IM compounds, IM breakdown products, and other munition compounds that are not currently included in U. S. Environmental Protection Agency (EPA) Method 8330B. The eight additional compounds included were nitroguanidine, 3-nitro-1,2,4-triazol-5-one, picric acid, 2,4-dinitroanisole, 2,4-dinitrophenol, 2-nitrophenol, 4-nitrophenol, and new surrogate ortho-nitrobenzoic acid (o-NBA). Analytical methods were developed to enable sensitive, simultaneous detection and quantitation of the 24 IM and legacy compounds, including two orthogonal high-performance liquid chromatography (HPLC) column separations with either ultraviolet (UV) or mass spectrometric (MS) detection. Procedures were developed for simultaneous extraction of all 24 analytes and two surrogates (1,2-dinitrobenzene, 1,2-DNB; o-NBA) from high- and low-level aqueous matrices and solid matrices, using acidification, solid phase extraction (SPE), or solvent extraction (SE), respectively. For low-level aqueous samples extracted by SPE, all compounds were recovered within current Department of Defense Quality Systems Manual (DoD QSM) Ver5.3 accepted limits for aqueous samples analyzed by EPA Method 8330B (57-135%), except NQ, which was consistently recovered at approximately 50%. Likewise, all compounds were recovered from six geographically/geochemically unique soil types within current QSM accepted limits for solid samples analyzed by EPA Method 8330B (64-135%). Further, the majority of compounds were recovered from four tissue types within current limits for solids, with generally low recovery only for Tetryl (from 4 to 62%). A preparatory chromatographic interference removal procedure was adapted for tissue extracts, as various analytical interferences were observed for all studied tissue types.