Antimicrobial Efficacy of Aqueous Ozone and Ozone-Lactic Acid Blend on Salmonella-Contaminated Chicken Drumsticks...

Ozone (O₃) is an attractive alternative antimicrobial in the poultry processing industry. The optimal operational conditions of O₃ for improving food safety concerns are poorly understood. The main objective of this study was therefore to characterize the microbial killing capacity of aqueous O₃ and O₃-lactic acid blend (O₃-LA) at different operational conditions on chicken drumsticks contaminated with high Salmonella load using sequential soaking and spraying approaches. Four hundred forty-eight chicken drumsticks (280-310 g) were soaked into two-strain Salmonella cocktail, and the initial load on the surface of the skin was 6.9-log₁₀ cell forming unit (CFU)/cm² [95% confidence interval (CI), 6.8-7.0]. The contaminated drumsticks were then sequentially (10×) soaked and sprayed with aqueous O₃ (8 ppm) and O₃-LA. Following O₃ exposure, quantitative bacterial cultures were performed on the post-soaking and post-spraying water, skin surface, and subcutaneous (SC) of each drumstick using 3M^TM Petrifilm^TM Rapid Aerobic Count Plate (RAC) and plate reader. The average killing capacity of aqueous O₃/cycle on the skin surface was 1.6-log₁₀/cm² (95% CI, 1.5-1.8-log₁₀/cm²) and 1.2-log₁₀/cm² (95% CI, 1.0-1.4-log₁₀/cm²), and it was 1.1-log₁₀/cm² (95% CI, 0.9-1.3-log₁₀/cm²) and 0.9-log₁₀/cm² (95% CI, 0.7-1.1-log₁₀/cm²) in SC for soaking and spraying approaches, respectively. Six sequential soaking and seven sequential spraying cycles with ozonated water of 8 ppm reduced the heavy Salmonella load below the detectable limit on the skin surface and SC of drumsticks, respectively. Addition of LA seems to increase the microbial killing capacity of aqueous O₃ with average differences of 0.3-log₁₀/cm² (P = 0.08) and 0.2-log₁₀/cm² (P = 0.12) on the skin surface using soaking and spraying approaches, respectively. Aqueous O₃ did not cause any significant changes in the drumstick skin color. The Salmonella load of < 4.5-log₁₀/cm² was a strong predictor for the reduction rate (P < 0.001, R ² = 0.64). These results provide important information that helps the poultry processing facilities for selecting the optimal operational strategy of O₃ as an effective antimicrobial.