Effect of Electrohydrodynamic (EHD) on Drying Kinetics and Quality Characteristics of Shiitake Mushroom

The effect of an electrohydrodynamic (EHD) drying system on the drying kinetics, microstructure and nutritional composition of shiitake mushrooms was studied. Shiitake mushroom slices were dried at 0, 18, 22, 26, 30 and 34 kV. The results showed that the drying rate, effective moisture diffusion coefficient and shrinkage of the EHD treatment group were significantly higher than those of the control group. The 34 kV treatment group had the highest drying rate (0.24 g W/g DM × h) and the highest effective moisture diffusion coefficient (1.01 × 10^-10 m²/s), which were 6.75 and 7.41 times higher than those of the control group, respectively. The control group had the highest rehydration ratio (7.72) and showed unsatisfactory color performance. The scanning electron microscopy (SEM) results showed that compared with the control group, the surface of samples dried by EHD exhibited different degrees of encrustation, and the area of encrustation increased with increasing voltage. After analysis by Fourier transform infrared (FTIR) spectroscopy, it was found that the samples of both the EHD-treated and control groups had similar absorption peak positions, but the intensity of the absorption peak of the EHD-dried samples was greater. Compared with the control group, the shiitake mushroom slices dried by EHD had a higher protein content and polysaccharide content. The polysaccharide content in 22 kV treatment group was the highest (4.67 g/100 g), and the protein content in 26 kV and 34 kV treatment groups was the highest (17.0 g/100 g). This study provides an experimental and theoretical basis for an in-depth study of the drying kinetics of shiitake mushrooms and provides theoretical guidance and clues for the wider application of EHD drying technology.