Effect of mild thermal and pH changes on the sol-gel transition in skim milk

The present work aimed to improve acid and rennet milk gelation properties with mild thermal and pH changes to skim milk, with emphasis on heating temperatures below the denaturation temperature of whey proteins. We hypothesized the heat-induced, pH-dependent micellar changes, namely the shifts in casein and calcium equilibria between the micellar (or colloidal) and serum phases, result in firmer acid and rennet milk gels and reduced gelation time. Homogenized, pasteurized skim milk was adjusted to pH values in the range of 6.4 to 7.3, heated at temperatures in the range of 50 to 80°C, cooled to refrigeration temperature, and restored to native pH (pH 6.7). Then, acid and rennet gels were made by the addition of glucono-δ-lactone and chymosin, respectively. We monitored the storage modulus (G', Pa) during gel formation with small-amplitude oscillatory shear and the gelation time and maximum G' (G'max, Pa) of acid and rennet gels, were measured at 3 and 2 h, respectively. When skim milk was heated at 50°C for 15 min, there was a 58 and 163% increase in the G'max of acid and rennet gels, respectively, as the pH at heating was raised from pH 6.7 to 7.3. Increases in gel strength were greater for skim milk heated at 60°C for 15 min. There was a positive correlation between G'max of acid gels and the heat-induced casein protein exchanges between the micellar and serum phases on heating milk at pH in the range from 6.4 to 7.3 (r = 0.78). We also found positive correlations between the variation in G'max of rennet gels with the heat-induced, pH-dependent migration of casein (r = 0.83) and calcium (r = 0.80) from the micelle into the serum phase, as determined by PAGE and atomic emission spectroscopy. Under these mild heating temperatures (50 and 60°C), rennet coagulation time was significantly reduced from 45 ± 5 to 27 ± 3 min when the pH at heating was raised from pH 6.7 to 7.3. The ability to enhance milk gelation properties with a scalable pretreatment allows for the expression of novel functionality of casein.