[Analysis of Efficency, Cost Structure and Revenues of ALT Free Flaps in Extremity Reconstruction]

Microvascular reconstructions can be lengthy procedures lasting the entire day. As a result of unforeseeable events, the standardization of these procedures can be challenging. Moreover, the length of these procedures varies strongly, which impedes adequate scheduling and, therefore, optimal capacity utilization. Within the years 2018-2020, the duration of ALT free flap extremity reconstructions was correlated with the experience of the microsurgeon (category 1:<50 free flaps life-time experience, category 2: 50-200, category 3:>200) and comorbidities. The resulting costs were compared with the matrix of the German DRG Institute InEK. The surgical experience of the microsurgeon had a significant impact on the duration of surgery in extremity reconstruction. In due consideration of potential complications, category 2 microsurgeons were 45 minutes faster and category 3 microsurgeons were 167 minutes faster than category 1 microsurgeons. Comorbidities, by contrast, did not have a significant impact on procedure duration. Cost analysis revealed deficits for these procedures in relation to the InEK matrix. However, an additional analysis showed that the duration of surgery was within the German average while costs for personnel/OR minute were slightly below the average. According to this calculation, costs for microsurgical training were approximately 1000€/case. The reimbursement for flaps in extremity reconstruction is not entirely mapped in the German DRG system. Given the longer procedure times, microsurgical training is associated with higher costs. Defining the duration of microsurgery based on the level of expertise should result in improved adherence to schedule and more efficient utilization of the valuable operating room time.