Preparation of small volume, leuko and erythrocyte very poor platelet concentrates

Recently developed automated discontinuous flow centrifuge (DFC) separators can produce leuko- and erythrocyte-poor platelet concentrates (PC). According to general experience with these machines it is difficult to obtain more than 4 X 10(11) platelets, though a second program set up by Coffe et al. appears to produce PC containing approximately 5 X 10(11) platelets suspended in a plasma volume of 390 ml. At our center we employed a new Dideco cell separator equipped with the surge pump and a technique developed for the production of small volume, RBC and WBC-very poor PC. In 60 routine procedures we obtained the following results: mean processing time 87 +/- 11 minutes; final volume of PC 136 +/- 19 ml, with a mean platelet yield of 5.21 X 10(11) platelets. WBC contamination was 1.8 X 10(8) (93% lymphocytes) and RBC were 3.1 X 10(8). Plasma volume as well as WBC and RBC contamination were reduced by recirculating PC after the 6th pass. The demand for single donor platelet concentrates (PC) is increasing progressively. Recently developed automated cell separators can produce leukocyte (WBC) and erythrocyte (RBC) poor PC. With these machines it may be difficult to obtain PC containing at least 4 X 10(11) platelets and less than 1 X 10(9) leukocytes (1, 2, 3) since donor variables such as hematocrit, precounts, buffy coat formation and initial plasma light transmission are of paramount importance for the efficiency of the program. At our center a prototype discontinuous flow centrifuge (DFC) cell separator equipped with the surge pump was studied.(ABSTRACT TRUNCATED AT 250 WORDS)