Related Experiment Video
Updated: Jul 16, 2025
Depolymerizable Olefinic Polymers Based on Fused-Ring Cyclooctene Monomers
Published on: December 16, 2022
Internal reuse of methanol-to-olefin wastewater based on micro-channel separation coupling hydrocyclone regeneration
Bing Liu1, Hongpeng Ma2, Qizhong Huang3
1National Engineering Laboratory for Industrial Wastewater Treatment, East China University of Science and Technology, Shanghai, 200237, China; State Environmental Protection Key Laboratory of Environmental Risk Assessment and Control on Chemical Process, East China University of Science and Technology, Shanghai, 200237, China.
Abstract:
Methanol-to-olefin (MTO) is a typical new coal chemical industry example. Due to the large volume of generated wastewater, complex composition including catalysts, aromatics and various oxygen-containing compounds, and serious environmental hazard, wastewater recycling is critical for sustainable industrial development and ecological protection. Herein, a swirl regenerating micro-channel separation (SRMS) technology was proposed to integrate deep filtration and hydrocyclone-enhanced regeneration. A small-scale experimental investigation was first conducted to verify the feasibility of the MTO wastewater treatment. A pilot SRMS device with a treatment capacity of 20 m3/h was constructed, and the device's continuous operation effect and stability were comprehensively evaluated. The separation performance of the SRMS device at different solution pH values and the impact of the hydrocyclone-enhanced regeneration of separation media were discussed in detail. At low solution pH values (<7), the SRMS device exhibits an average separation efficiency of 92.0% for fine particulate matter in wastewater, and the median particle size, d50, decreases from 1.55 to 0.6 μm. As the solution pH increases, the repulsive energy barrier for the medium-contaminant and contaminant-contaminant increases, inhibiting the deposition behavior of particulate pollutants. In addition, hydrocyclone desorbs contaminants deposited on the separation media and the average contaminant residual rate decreases from 3.3 to 0.2 wt%. We propose an industrial application for treating and reusing MTO wastewater (200 m3/h) using the SRMS technology based on the experimental results. The costs of the wastewater treatment process are as low as 0.25 CNY/m3, and the wastewater reuse rate is over 97% without chemical consumption. This work can provide an environmentally friendly and economically sustainable approach to the source management of MTO wastewater.
