Pilot study on ceramic flat membrane bioreactor in treatment of coal chemical wastewater

Some toxic and refractory pollutants in coal chemical wastewater can penetrate the biochemical treatment systems and cause high concentrations of suspended solids in the effluent, which may obstruct the subsequent advanced treatment. In this project, a submerged ceramic plate membrane system was integrated to the last oxic corridor of an existing multistage anoxic/oxic tank. In the ceramic flat membrane bioreactor, the influent chemical oxygen demand (COD) was 102.24-178.88 mg/L, with a removal ratio of approximately 30%. The NH₃-N concentration in the effluent was relatively stable with an average value of 1.76 mg/L. The turbidity of the effluent was in the range of 0.235-0.852 NTU and was stable below 1 NTU. A flux of 30 L m^-2·h^-1 could meet the requirements of the pilot test. A gas-water ratio of 50:1 was found optimal. When the concentration of mixed liquor suspended solids (MLSS) was >3769 mg/L, the extracellular polymeric substance in the mixed solution was utilized by microorganisms as a substrate. High MLSS decreased membrane fouling rate. NaClO backwashing can effectively remove pollutants without adversely affecting the treatment efficiency of membrane bioreactors.