Microstructure investigation, Electrical properties, and γ-rays' protection capacity for ZnO doped clay ceramic

A series of ceramic samples fabricated based on ZnO doped different concentrations of natural clay according to the relation (1-x) ZnO - (x) clay; 5 wt% ≤ x ≤ 20 wt%. The samples were pressed and sintered at 1200 °C. The experimental techniques were used to characterize and measure the chemical composition, density, and current-voltage measurements for the fabricated ceramics samples. The measurements depict an increase in the I-V nonlinearity with raising the clay concentration, where the increase in clay by up to 20 wt% shifts breakdown voltage to a higher value of up to 390 V/cm and decreases leakage current to 55 mA/cm². The examinations for the gamma-ray shielding capacity for the fabricated composites (utilizing Monte Carlo simulation) demonstrate enrichment of clay concentration between 5 wt% and 20 wt% reduced the linear attenuation coefficient for the fabricated ceramics by 23.15% and 8.66% at γ photon energy of 0.059 MeV and 1.252 MeV, respectively. The half-value thickness and lead's equivalent thickness increased along with a drop in the linear attenuation coefficient, but the radiation protection effectiveness of the fabricated ceramics increased.