Related Experiment Video
Updated: Jun 22, 2026
Metacarpal Small Incision for Carpal Tunnel Syndrome
Published on: April 5, 2024
Direct Variable Cost Comparison of Endoscopic Versus Open Carpal Tunnel Release: A Time-Driven Activity-Based Costing
Terence L Thomas1, Graham S Goh, Pedro K Beredjiklian
1From the Rothman Orthopaedic Institute at Thomas Jefferson University, Philadelphia, PA (Thomas, Beredjiklian), and the Department of Orthopaedic Surgery, Boston University Medical Center, Boston, MA (Goh).
Introduction:
To improve the delivery of value-based health care, a deeper understanding of the cost drivers in hand surgery is warranted. Time-driven activity-based costing (TDABC) offers a more accurate estimation of resource utilization compared with top-down accounting methods. This study used TDABC to compare the facility costs of open carpal tunnel release (OCTR) and endoscopic carpal tunnel release (ECTR).
Methods:
We identified 845 consecutive, unilateral carpal tunnel release (516 open, 329 endoscopic) surgeries performed at an orthopaedic specialty hospital between 2015 and 2021. Itemized facility costs were calculated using a TDABC algorithm. Patient demographics, comorbidities, surgical characteristics, and itemized costs were compared between OCTR and ECTR. Multivariate regression was used to determine the independent effect of endoscopic surgery on true facility costs.
Results:
Total facility costs were $352 higher in ECTR compared with OCTR ($882 versus $530). ECTR cases had higher personnel costs ($499 versus $420), likely because of longer surgical time (15 versus 11 minutes) and total operating room time (35 versus 27 minutes). ECTR cases also had higher supply costs ($383 versus $110). Controlling for demographics and comorbidities, ECTR was associated with an increase in personnel costs of $35.74 (95% CI, $26.32 to $45.15), supply costs of $230.28 (95% CI, $205.17 to $255.39), and total facility costs of $265.99 (95% CI, $237.01 to $294.97) per case.
Discussion:
Using TDABC, ECTR was 66% more costly to the facility compared with OCTR. To reduce the costs related to endoscopic surgery, efforts to decrease surgical time and negotiate lower ECTR-specific supply costs are warranted.
Level Of Evidence:
Economic and Decision Analysis Level II.
