Related Experiment Video
Updated: Jun 24, 2025
Ex Vivo Porcine Experimental Model for Studying and Teaching Lung Mechanics
Published on: April 19, 2024
Proof-of-principle of a lung sealant based on functionalized polyoxazolines: experiments in an ovine acute aerostasis
Bob P Hermans1, Richard P G Ten Broek2, Wilson W L Li1
1Department of Cardio-Thoracic Surgery, Radboud University Medical Center, Radboud Institute for Health Sciences, Nijmegen, Netherlands.
Objectives:
More effective lung sealants are needed to prevent prolonged pulmonary air leakage (AL). Polyoxazoline-impregnated gelatin patch (N-hydroxysuccinimide ester functionalized poly(2-oxazoline)s; NHS-POx) was promising for lung sealing ex vivo. The aim of this study is to confirm sealing effectiveness in an in vivo model of lung injury.
Methods:
An acute aerostasis model was used in healthy adult female sheep, involving bilateral thoracotomy, amputation lesions (bronchioles Ø > 1.5 mm), sealant application, digital chest tube for monitoring AL, spontaneous ventilation, obduction and bursting pressure measurement. Two experiments were performed: (i) 3 sheep with 2 lesions per lung (N = 4 NHS-POx double-layer, N = 4 NHS-POx single-layer, N = 4 untreated) and (ii) 3 with 1 lesion per lung (N = 3 NHS-POx single-layer, N = 3 untreated). In pooled linear regression, AL was analysed per lung (N = 7 NHS-POx, N = 5 untreated) and bursting pressure per lesion (N = 11 NHS-POx, N = 7 untreated).
Results:
Baseline AL was similar between groups (mean 1.38-1.47 l/min, P = 0.90). NHS-POx achieved sealing in 1 attempt in 8/11 (72.7%) and in 10/11 (90.9%) in >1 attempt. Application failures were only observed on triangular lesions requiring 3 folds around the lung. No influences of methodological variation between experiments was detected in linear regression (P > 0.9). AL over initial 3 h of drainage was significantly reduced for NHS-POx [median: 7 ml/min, length of interquartile range: 333 ml/min] versus untreated lesions (367 ml/min, length of interquartile range: 680 ml/min, P = 0.036). Bursting pressure was higher for NHS-POx (mean: 33, SD: 16 cmH2O) versus untreated lesions (mean: 19, SD: 15 cmH2O, P = 0.081).
Conclusions:
NHS-POx was effective for reducing early AL, and a trend was seen for improvement of bursting strength of the covered defect. Results were affected by application characteristics and lesion geometry.
