Mucus transport and surface damage after endotracheal intubation and tracheostomy. An experimental study in pigs

The effects on mucus transport of different grades of tracheal injury produced experimentally by an intubation tube were studied in 26 pigs. Two of them were not intubated and served as controls, while the rest were anaesthetized and either intubated or tracheostomized, or both, and ventilated for approximately 4.5 h. They were then killed and the trachea and larynx were immediately removed and placed in a specially designed chamber at 37 degrees C and 85% relative humidity. Cardio-green dye was deposited caudally in the trachea as a mucus marker. The mucus transport was observed macroscopically and the ultrastructure of the tracheal wall at the region of mucus arrest was studied by light microscopy and scanning and transmission electron microscopy. In non-intubated pigs the mucus was transported to the posterior larynx. The ciliated epithelium was usually intact along the pathway where cardio-green-stained mucus had travelled. In pigs which had been intubated and/or tracheostomized, mucus transport stopped completely at different levels of the trachea. The damage to the ciliated epithelium varied; in some animals there was almost none at all and in others there was a patchy loss of a large proportion of the cilia, or complete lack of cilia. Lesions which also included epithelial cells were often seen. Tracheal injury due either to a cuffed endotracheal tube or to a tracheostomy tube, with destruction of epithelium and cilia, causes a barrier to mucus transport, leading to arrest and accumulation of mucus further down in the airway. We were unable, however, to demonstrate a direct correlation between grade of damage and tendency to mucus arrest.