Evaluation of an extracorporeal membrane oxygenation system using a nonporous membrane oxygenator and a new method...

A new heparin binding method was applied to a miniature extracorporeal membrane oxygenation (ECMO) system with a nonporous membrane oxygenator (the priming volume, 45 mL; the membrane surface area, 0.4 m2; maximal flow rate, 2 L/min) that is resistant to plasma leakage. The authors evaluated the stability of the immobilized heparin in vitro and the feasibility of this system in animals. Samples of hollow fibers and tubing were rinsed at 40 degrees C for 4 days in normal saline, Ringer's lactate, and 1 mol/L NaCl solution. Heparin activities on hollow fibers after rinsing were 99 +/- 2.3% (mean +/- SD), 96 +/- 3.9%, and 93 +/- 2.0% of the control in each solution, while those of the tubing were 87 +/- 4.1%, 86 +/- 3.1%, and 76 +/- 8.6%, respectively. Veno-arterial ECMO using this heparin-coated system was performed on five beagles (8 to 12 kg) for 10 hours. Neither major thrombus formation nor plasma leakage was detected during the procedure in spite of a low flow rate (300 mL/min) and a reduced activated clotting time (mean, 128 seconds). Platelets decreased to 52% of the control (P < .01) at 1 hour, but no progressive decrease was seen thereafter. Antithrombin-III decreased (P < .01) and thrombin/antithrombin III complex increased (P < .05 at 4 hours and P < .01 at 6, 8, and 10 hours) during bypass, but the changes of fibrinogen and fibrinopeptide A were not significant. Fibrinogen/fibrin degeneration products, fibrinopeptide B beta 15-42, and plasma-free hemoglobin levels did not rise significantly. O2 transfer of the oxygenators at a flow rate of 300 mL/min were 12.3 +/- 0.4 mL/min at 30 minutes, 14.3 +/- 1.2 mL/min at 5 hours, and 14.7 +/- 1.7 mL/min at 10 hours (no statistical difference). Histological examination of the brains and the kidneys showed no evidence of thromboembolic sequela in any of the animals. These results suggest that this new system is a promising device for long-term ECMO in which the amount of systemic heparinization can be reduced with the minimal possibility of plasma leakage.