Effect of specific gas loading rate on thermophilic (55 degrees C) acidifying (pH 6) and sulfate reducing granular...

The effect of the specific gas loading rate on the acidifying, sulfate reducing and sulfur removal capacity of thermophilic (55 degrees C; pH 6.0) granular sludge bed reactors treating partly acidified wastewater was investigated. A comparison was made between a regular UASB reactor and a UASB reactor continuously sparged with N(2) at a specific gas loading rate of 30 m(3)m(-2)d(-1). Both UASB reactors (upflow velocity 1.0 mh(-1), hydraulic retention time about 5h) were fed a synthetic wastewater containing starch, sucrose, lactate, propionate and acetate and a low sulfate concentration (COD/SO(4)(2-) ratio of 10) at volumetric organic loading rates (OLR) ranging from 4.0 to 49.8 gCODl(-1) reactord(-1). Immediately after imposing an OLR of 25 gCODl(-1) reactord(-1), the acidification and sulfate reduction efficiency dropped to 80% and 30%, respectively, in the UASB reactor. Both efficiencies recovered slowly to 100% during the course of the experiment. In the N(2) sparged reactor, both the acidification and sulfate reduction efficiency remained 100% following the OLR increase to 25 gCODl(-1) reactord(-1). However, the sulfate reduction efficiency gradually decreased to about 20% at the end of the experiment. The biogas (CO(2) and CH(4)) production rate in the UASB was very low, i.e. <3l biogasl(-1) reactorday(-1), resulting in negligible amounts (<20%) of H(2)S stripped from the reactor liquid. The total H(2)S concentration of the N(2) sparged UASB reactor effluent was always below 25 mgl(-1), but incomplete sulfate reduction kept the maximal H(2)S stripping efficiency below 70%.