Pre-operative planning and rod customization may optimize post-operative alignment and mitigate development of...

Patient-specific rods designed based on a particular pre-operative plan are a recent advancement to help achieve desired operative alignment goals. This study investigated the role of pre-operative planning and patient-specific rods on post-operative alignment and outcomes. Patients were grouped according to use of pre-operative planning and patient-specific, pre-contoured rods (PLAN) or absence of planning/rods (NON). Pre-operative and post-operative alignment were measured: cervical sagittal vertical axis (cSVA), cervical lordosis (CL), T1 Slope minus CL (TS-CL). Alignment differences between the groups were assessed using independent and paired samples t-tests. 34 patients were identified (15 PLAN, 19 NON). Pre- and post-operative CL, cSVA and TS were similar between the two groups (p > 0.05), though pre-operative TS-CL was slightly higher in PLAN patients (28.13° versus 18.42°, p = 0.049). There were no improvement differences pre- to post-operative for CL, cSVA and TS between the groups (p > 0.05). However, PLAN patients exhibited a greater correction of TS-CL, with an average of 5.8° decrease versus a 3.5° increase in TS-CL for NON patients (p = 0.015). PLAN patients did not demonstrate a significant change from pre- to post-operative alignment for cSVA or TS-CL (cSVA: 27.5 mm to 31.1 mm, p = 0.255; TS-CL: 28.1° to 22.3°, p = 0.13), though their TS-CL did trend towards significant post-operative improvement. In contrast, NON patients worsened in cSVA and TS-CL post-operatively (cSVA: 21.8 mm to 30.3 mm, p < 0.001; TS-CL: 18.4° to 22.0°, p = 0.035). Multi-segment posterior decompression and fusion patients have the potential to worsen with regards to post-operative alignment without pre-operative planning. Patients with pre-contoured rods and pre-operative planning exhibited a greater correction of TS-CL after surgery than un-planned cases, though limited by the pre-operative difference in cervical-thoracic mismatch between planned and unplanned cases. LEVELS OF EVIDENCE: III.