Purification, characterization, and identification of 3-hydroxy-4-methoxy benzal acrolein-an intermediate of...

Advantame is a novel sweetener, and 3-hydroxy-4-methoxy benzal acrolein is an important intermediate to synthesize the sweetener. The aim of this study was to evaluate a new low-cost method to purify 3-hydroxy-4-methoxy benzal acrolein, and the crude intermediate was used as raw material. The intermediate was purified using a low-pressure column chromatography with a C₁₈ column, using a methanol-water (6:4, v/v) at a flow rate of 6.0 ml/min, and the loading amount of the crude intermediate in solution was 10.0 mg in total. A method for the analysis of 3-hydroxy-4-methoxy benzal acrolein was established using high-performance liquid chromatography (HPLC). This method was validated in terms of its linearity, repeatability, accuracy, detection limit, and quantitation limit. The calibration curves of 3-hydroxy-4-methoxy benzal acrolein were linear (r > .999) over a wide concentration range of 0.005-0.08 mg/ml, by comparing the ratio of signal to noise, and the detection limit was 5.0 ng/ml and the quantification limit was 15.0 ng/ml. Good repeatability was obtained (RSD < 2%, n = 6), and the recoveries calculated using mixed sample previously quantified ranged from 94.5% to 106.37%. As long as, this method has been successfully applied to the analysis of 3-hydroxy-4-methoxy benzal acrolein; therefore, the method can be put into practical use during the industrial synthesis and real-time detection of the intermediate.