Why can hydrothermally pretreating lignocellulose in low severities improve anaerobic digestion performances?

A lignocellulosic residue, rice straw, was hydrothermally pretreated for the whole slurry anaerobic digestion. In contrast to the unpretreated rice straw, 110-120 °C pretreatment promoted biogas yield by 35%-38%, while only 14% promotion happened on the pretreatment at 180 °C. To understand why this improvement happened at lower severities, the pretreated rice straw at 90 °C, 120 °C, and 180 °C were selected for the further investigation, in which the liquor and solid fraction were separated for digestion, and compared with the whole slurry digestion. Results indicated more methane was released from the derived liquor of 180 °C than that of 90 °C and 120 °C, however, solid fraction did not exhibit significantly different methane yields (187.77-193.91 mL/g TS). These results suggested that the released soluble fraction from pretreatment could facilitate the methanogenesis. Furthermore, the released inherent soluble fraction in rice straw was mainly responsible for higher biogas yield at lower temperatures. Pretreatment at higher temperatures disintegrated the rice straw recalcitrance more, and intensified the release of soluble fraction accordingly. Consequently, the methanogenesis of whole slurry could be promoted at the initial digestion; the hydrolysis/acidification of the solid fraction in whole slurry was weakened greatly, which resulted in a lower biogas yield. This can also be proved by the evolution of dominant bacteria and archaea in the anaerobic digestion of whole slurry, separated solid and liquor fraction.