Heat treatment of milk protein concentrates affects enzymatic coagulation properties

Dairy ingredients with highly concentrated protein contents are high added value products with expanding market. The manufacture of such ingredients includes a succession of unit operations of which heat treatment is a key step to guarantee the microbial safety, that induces major changes in protein structures and thus ingredients functionalities. However, due to an incomplete understanding of phenomena taking place at high protein concentrations, shedding light on their mechanisms is a scientific challenge as well as an industrial need. In this study, the influence of heat treatment (74 °C/ 30 s) of highly concentrated milk protein systems (up to 20 % w/w) on protein denaturation/aggregation and enzymatic coagulation properties was studied using an original semi-industrial approach. 10 % w/w protein solutions constituted with whey protein and casein micelles at milk ratio, standardized in osmosed water or ultrafiltration permeate were used. These protein solutions were processed in different ways prior the manufacture of powders: heat treatment of the 10 % w/w protein solution before vacuum evaporation, heat treatment of the 20 % w/w protein solution after vacuum concentration, two consecutive heat treatments before and after vacuum evaporation. A fourth powder was prepared from unheated 10 % w/w protein solution. An increase in protein concentration led to a higher heat-induced protein denaturation. This phenomenon was reduced when increasing the lactose content. The effect of heat treatment on the extent of protein denaturation was not cumulative. At high protein concentration, interactions between κ-casein and whey protein were modified compared to milk, as mainly micelle-bound aggregates were formed at pH about 6.7. This phenomenon was enhanced at low ionic strength and lactose content. Our study showed that the enzymatic coagulation properties of reconstituted protein powders could be correlated with their physico-chemical compositions. An increase in protein denaturation disrupted the gel reorganization and led to the formation of weaker gels but did not interfere on the micelles aggregation phase and the early gelation. On the contrary, an increase in ionic strength and lactose content led to higher gel time.