Related Experiment Video
Updated: Aug 11, 2025
In Ovo Feeding of Commercial Broiler Eggs: An Accurate and Reproducible Method to Affect Muscle Development and Growth
Published on: September 20, 2021
Utilizing in ovo telemetry to examine the effects of reduced incubation temperature on broiler embryo temperature and
L L Lindsey1, K E C Elliott2, S A Fatemi1
1Department of Poultry Science, Mississippi State University, Mississippi State MS 39762, USA.
Abstract:
The current commercial broiler embryo experiences a rapid metabolism and growth rate and may produce more heat than those of the past. Consequently, it may be beneficial to lower standard incubation temperature for commercial broiler hatching eggs. The purpose of this experiment was to determine if lowering incubation temperature at 12 d of incubation (DOI) would affect embryo temperature (ET) in embryonated Ross 708 broiler hatching eggs. From 0 to 12 DOI, eggs were incubated under standard conditions (37.50°C dry bulb, 29.76°C wet bulb). At 12 DOI, temperature transponders were aseptically placed on the inner air cell membrane to measure air cell temperature (ACT) as an estimate of ET in 120 eggs. The eggs were then randomly assigned to 4 separate still-air incubators, each containing 30 eggs. Two replicate incubators were maintained at a standard (STRT; 37.5°C) or low (LTRT; 35.6°C) temperature treatment between 12 and 21 DOI. A significant positive correlation existed between incubator air temperature (IAT) and ACT across temperature treatment and in the STRT. However, IAT was not significantly correlated with ACT in the LTRT. A significantly higher ACT was observed in the STRT than in the LTRT for 88% of the readings taken between 12 and 21 DOI. Percent egg weight loss (PEWL) between 13 and 17 DOI did not significantly differ between temperature treatments. From 13 to 17 DOI, there was a significant positive correlation between PEWL and ACT in the STRT, however, no significant correlation occurred between PEWL and ACT in the LTRT. Percent hatch of fertile eggs containing live embryos at 12 DOI was 93.3% in the STRT and 100% in the LTRT. However, time of hatch occurred 14 to 19 h later and hatchling BW was lower in the LTRT than in the STRT. Although lowering IAT at 12 DOI may improve hatchability, an associated delay in hatch and a decrease in hatchling BW may not be commercially acceptable.
