Lipid-rich particles of processed food waste for microalgae harvest through lipid-enriched floating biomat formation

Food waste was collected from the campus canteen and lipid-rich particles (LRP) phase was evaluated to harvest Tetradesmus obliquus. Box-Behnken design showed the highest harvest efficiency (HE) of 84.69 % in run#1 (LRP = 30 %; initial OD₆₈₀ = 1.75; and harvest time = 6 h). Numerical optimization ramps suggested 24.15 % (v/v) LRP ratio, initial OD₆₈₀ 3.00, and harvest time 3.82 h for maximum HE. Two flocs were observed, a precipitate at the bottom (B-Floc) and a floating biomat (F-Floc). Experimental results showed HE of 88.3 %, with 67 % and 33 % of the harvested biomass forming F-Floc and B-Floc, respectively. Pre-heating of LRP in a boiling water bath for 10 min (HFB-T10) promoted F-Floc proportion up to 91.6 %. In addition, HFB-T10 showed the highest FAMEs yield of 11.17 g/L of the total used volume, which was significantly higher than that of the centrifuged cells and heat-untreated biomat. Moreover, HFB-T10 showed better iodine value and cetane number of the produced biodiesel.