Effects of head restraint (HR) interference on child restraint system (CRS) performance in frontal and far-side...

Forward-facing child restraint systems (FF CRS) and high-back boosters often contact the vehicle seat head restraint (HR) when installed, creating a gap between the back surface of the CRS and the vehicle seat. The effects of HR interference on dynamic CRS performance are not well documented. The objective of this study is to quantify the effects of HR interference for FF CRS and high-back boosters in frontal and far-side impacts. Production vehicle seats with prominent, removeable HRs were attached to a sled buck. One FF CRS and two booster models were tested with the HR in place (causing interference) and with the HR removed (no interference). A variety of installation methods were examined for the FF CRS. A total of twenty-four tests were run. In frontal impacts, HR interference produced small but consistent increases in frontal head excursion and HIC36. Head excursions were more directly related to the more forward initial position rather than kinematic differences caused by HR interference. In far-side impacts, HR interference did not have consistent effects on injury metrics. Overall, these results suggest only slight benefits of removing the HR in frontal impacts specifically. Caregivers should use caution if removing a vehicle HR to ensure that the current child occupant and all future vehicle occupants have adequate head support available in case of a rear impact.