Staphylococcal enterotoxin B and nuclease production under controlled dissolved oxygen conditions

Enterotoxin B, nuclease, and total exoprotein production by Staphylococcus aureus strain S-6 was studied in a 0.5-liter fermentor system. While these extracellular products were elaborated over a wide range of aeration rates, maximal production occurred within the very narrow range of 125 to 150 cm(3) of air per min. The levels attained at the optimal aeration rate were not increased by maintaining a constant pH, although yield of enterotoxin:cell mass was highest at a constant pH of 7.0. During the growth cycle of the cultures, when aeration rate alone or aeration rate and pH were held constant, the dissolved oxygen (DO) levels, initially set at 100% of saturation, decreased to 5 to 10% 4 to 5 h after inoculation. The oxygen demand of the culture then maintained this level for an additional 4 to 6 h. This interval of low DO was characterized by maximal growth and exoprotein production. When the DO was controlled at a constant value throughout growth (by increasing or decreasing the airflow rate as appropriate), the culture demonstrated different optima for maximal growth and exoprotein production. A constant DO of 100% stimulated growth to extremely high densities, but the accumulation of toxin and nuclease was not observed. On the other hand, maintaining constant DO levels at 50 or 10% raised exoprotein levels higher than those achieved in a culture grown at the optimal aeration rate. Compared to the optimal aeration rate culture, the 10% DO culture yielded 20% more nuclease, 25% more toxin, and 40 to 50% more total exoprotein. These results indicate that it is the DO and not the aeration rate, per se, that is influential in controlling growth, toxin, nuclease, and total exoprotein production.