Mechanism of production of crackles after atelectasis during low-volume breathing

We compared the effects of shallow breathing of air (LVB-air) and oxygen (LVB-O2) at low lung volumes (below closing capacity) and tidal breathing at FRC (FRC-air, FRC-O2) on the production of crackles in 5 normal volunteers. Two microphones were attached on the right posterior chest wall in the midclavicular line 10 and 20 cm from the apex of the right lung, respectively (M10 and M20), to record crackles during various breathing maneuvers. We found that after LVB-air and LVB-O2, there were changes in residual volume as measured by the body plethysmograph. Both inspiratory and expiratory limbs of the quasi-static pressure volume curve were shifted to the right. Occasionally, some subjects coughed after LVB-air and/or LVB-O2. Inspiratory crackles occurred mostly at the upper third of vital capacity (VC) after LVB-air and LVB-O2 and were confined almost exclusively to the dependent lung zones (M20). The inspiratory transpulmonary pressure at 25% (PL25) and 50% (PL50) of VC correlated with the volume of trapped gas that was absorbed (delta Vtg) (p less than 0.001 and p less than 0.001, respectively). The quantity of crackles correlated with delta Vtg (p less than 0.01). We conclude that during low lung volume breathing airways in the dependent lung regions are closed. There is absorption of trapped oxygen which causes reversible atelectasis. Upon reinflation, inspired air will go to the lung regions with open airways first and subsequently to the closed dependent regions, producing crackles recorded by the M20 microphone at the upper third of VC. The crackles are produced by inflation of atelectatic lung.