Related Experiment Video
Updated: May 15, 2026
Use of the Scissor-Type Knife During the Peroral Endoscopy Myotomy Procedure for the Treatment of Achalasia
Published on: March 3, 2023
Comparison of plastic and metallic single-use and metallic reusable laryngoscope blades: a randomised controlled
Clément Buléon1, Jean-Jacques Parienti, Anne Lesage
1Caen University Hospital, Department of Anaesthesiology and Intensive Care, Caen, F-14000, France. buleon-c@chu-caen.fr
Context:
Plastic single-use laryngoscope blades have been found to increase the difficulty of intubation. Metallic single-use blades may represent an alternative.
Objective:
To compare the rates of intubation failure at first laryngoscopy using metallic single-use, plastic single-use and metallic reusable laryngoscope blades.
Design:
Randomised, superiority, single-centre, controlled trial.
Setting:
Operating theatres at a University Hospital from January 2008 to August 2009.
Patients:
A total of 1863 adults requiring general anaesthesia.
Intervention:
Patients were randomised to one of three laryngoscope blades: metallic single-use, plastic single-use or metallic reusable.
Main Outcome Measure:
The primary end-point was the number of intubation failures at first laryngoscopy. Secondary end-points were glottic exposure and the Intubation Difficulty Scale.
Results:
The failure rate (absolute difference: 95% confidence interval) at the first attempt was greater for the plastic single-use blades (8.1%) than for the metallic reusable [3.2% (4.9%: 2.2 to 7.6%); P < 0.001] and metallic reusable blades [4.0% (4.0%: 1.2 to 6.9%); P < 0.006]. No difference was found between the metallic reusable and metallic single-use groups (0.9%: -1.3 to 3.1%). Scoring on the Intubation Difficulty Scale [median (interquartile range)] was higher in the plastic single-use group [1 (0 to 2)] than in the metallic groups [metallic reusable: 0 (0 to 1); P < 0.001 and metallic single-use: 0 (0 to 1); P < 0.007] groups. Glottic exposure was significantly better in the metallic reusable group (modified Cormack & Lehane score III and IV: 3.7%) compared with the plastic single-use group (modified Cormack & Lehane score III and IV: 9.4%; P < 0.03).
Conclusion:
The rates of failed intubation at first laryngoscopy were similar in the metallic reusable and metallic reusable groups, but greater in the plastic single-use group.
